Charge quality for the sealed lead-acid batteries and emerging lithium-ion technologies used in the golf market is attained through charge profiles validated in our battery lab. To check this, remove the charger from the wall and inspect the connector and see if the pins are all up properly. To air your golf cart tire you can use an electric pump. Charge the cart then let it sit for about a hour after the charge cycle is finished. It does not only transport you and the golf accessories to the golf field but also it is very fun and relaxing to ride on. The issue might be worn-out coils or loose connections. As the state of charge in a battery decreases, the electrolyte becomes more like water and the freezing point increases. If anyone's battery has a reading that is below 12 volts per cell, then your charger needs to be replaced. In some cases, depending on the battery, you may add new plates and restore some charging functionality, but if the battery is damaged beyond this, you would have to replace it or them. If so, you're not alone. Every tire has an expiration time. Many people have had problems with their golf cart batteries not holding a charge. Firstly, you should try to reset the motor and fix the issue. It may be better to refer them to a qualified technician to resolve solenoid or direction switch issues, especially if you have thoroughly checked the other possible charging problems. Wait 10 seconds and turn the key to the on position, wait 10 seconds and turn the key off. What to do if your Golf Cart Battery Charger will not shut off. If it doesnt, you may need to contact the supplier or technician to enquire about repairs or replacing the cable. Cartaholic. Refrain from flooring the accelerator or overloading it. Just charge them up, and they're ready to go. Recharge the pack every 2 weeks if the car is sitting idle or in storage, and when in doubt, recharge it. If you decide to get warranty work done outside of the dealer who sold you your cart, the parts will be supplied to the non-selling dealer from the Manufacturer, however, the non-selling dealer may or may not charge labor. E-Z-GO recommends that electric golf car chargers remain unplugged from the golf car during prolonged storage. Remove the battery from the charger and then wipe the metal contact terminals on the battery with a dry cloth or cotton wool to ensure they are free of corrosion. I don't think we have anything conclusive yet and I think there are many factors that could be giving us all different results we should consider. Your golf cart may not be charging because you have a battery problem, your charger itself is faulty, the connections on the batteries, wiring, or charger cable are faulty, or there are faults with the golf cart electronics. Since your charger isnt working, you may need to use a general battery charger like our favorite on Amazon before using your golf cart charger. When I was a toddler, my family had a lush green lawn. Replace the parts if any one of these are broken. Reliability comes from every charger being sealed to an IP66 rating to avoid damage from vibration, water, dust and chemicals. When you connect the charger, the charge indicator lights up to show the battery percentage. The wires might be damaged, affecting current flow. We are having the same issue with our i40 we purchased 6 weeks ago. You may follow the below methods if your icon golf cart encounter has encountered motor related problems. This is a common issue behind a problematic brake. If it is not charged, then recharge it immediately. If you have had an encounter with overheating before, it is likely the cause of the issue at hand. Follow the steps above to charge each battery one by one to bring up the voltage.if(typeof ez_ad_units!='undefined'){ez_ad_units.push([[300,250],'betterplaygolf_com-large-mobile-banner-2','ezslot_9',122,'0','0'])};__ez_fad_position('div-gpt-ad-betterplaygolf_com-large-mobile-banner-2-0'); Many golf carts use Floating Lead Acid batteries, which require topping up because they are the cheapest and most readily available. You may not consider yourself a professional expert in fixing these problems. The wearing out can be due to a high current passing through the coils. If this did not work and/or the gauge continues to act abnormal, contact your dealer for a replacement gauge cluster. In warmer climates, and during the summer, watering is required more often. If the tangling led to their destruction, you must replace them. How To Fix EZGO 48 Volt Golf Cart Wont Move Problems? 36v Golf Cart using 3 12v Batteries - Surprising range. Classic 2 PRO. The tire might get flat due to a lot of pressure or vibrations. How To Fix Battery Issues in ICON Golf Carts. Assess the motor and its assembly thoroughly to know what is ailing it. Dispose of rag or paper towel. If you are a golf lover, then golf carts are a must-have vehicle for you. Golf carts are an essential part of golf for those who love golf. Classic 2 PLUS. As discussed above, you need to top up or refill your distilled water and only use DISTILLED WATER for your batteries; never use tap water. The main issue related to the motor problem is motor burnout. The Club Car brand typically has an on board charging circuit. Also, you may hear a noise indicating that the brake is problematic. The Icon golf cart i40 series has a seating capacity of up to four people. However, make sure not to overcharge them. Overall AGM batteries are a great option for use in golf cars. Undo the terminals from the battery posts and soak the corroded area in the cleaner or baking soda solution for about 5 or so minutes, then put on some gloves, grab your wire brush, and keep scrubbing until it's all gone. patterns are measured in a straight line from center to center of two bolt holes sitting directly across from each other. Club Car recommends that electric golf car chargers be left plugged in to the golf car during prolonged storage. This can become faulty and cause your golf cart not to charge. Yes, batteries can freeze if they are left in a state of partial or complete discharge. An Icon golf cart can last for about 4-5 years if you maintain them properly. That will make the brake stronger. Lithium batteries are very light compared to traditional batteries. Painting a golf cart with krylon fusion: How To Do It Right? This is a common phenomenon for having a battery-related problem in your Icon golf cart. Clean the overflow with a rag or paper towel by wiping directionally away from the ports. As a result, golf cart battery chargers for 48 volt Club Cars need a working OBC to get them to start charging. You should also make sure the brake is on and that the cart is in the park. When your golf cart doesnt charge, go through checking the batteries first to establish whether this is the problem. Furthermore, the electric motor brush kits price range is form 10 $ to 29 $. They have been telling me they are trying to get a fix from Icon in Tampa. Remove the motor from Cart and check the condition of individual parts e.g. What Size Garage Door Do You Need For A Golf Cart? The issue is primarily due to loose bolts and connections, which may affect the carts running. We bought it from the original buyers at the end of last. A faulty motor is a culprit behind some ICON golf cart problems, such as a hard start and sudden stalling. Its between 15 to 25 pounds per square inch. However, these electric models can sometimes act up. Spoke to the guy delivering and asked about the SOC issue. Repeat this for the first 10 20 cycles. If you fail then just move to experienced service providers. If you press the pedal very frequently like a racing car and hit the metal part of the cart, then it will put pressure on your motor, and ultimately, it might get burnout. Step 2. Furthermore, damaged or rusted terminal wires can be another reason for the battery problem. The next step is to check the golf cart charger itself. Golf Cart Issues. DO NOT let it touch your skin or clothing. Cant find the answer(s) you are looking for? Golf cart batteries are not designed to be discharged that often and so deeply; this is why they should be recharged after each round to avoid depletion and the risk of damage. Can You Mix Old and New Golf Cart Batteries? Yes, proper care of your batteries can maintain a longer life. Because this is an electrical environment, any loose or faulty connections, frayed or old wiring, or residue build-up on the connections or terminals can create issues with current flow. Sep 23, 2017. The following are the probable solutions to the overinflated tire problem. The signs to know that there are some problems with the brake are- the feel of the brake pedal may change if pushed. It comes with premium features like a 48V ICON 5KW 3 Phase High Torque motor, 4-wheel disc brakes, powder-coated steel chassis, a speed limit of 25 mph, lights, and turn signals. Distilled water only. In a nutshell, we have covered the most common ICON golf cart problems, their types, possible solutions, and the approximate cost to repair the cart. If your golf carts batteries are dead, then you will need to replace the battery with a brand new one. As an estimate, AGM and flooded lead acid batteries self-discharge approximately 4% per week at 80F. Lithium Batteries Substantially Reduce the Weight of Your Golf Cart. Recharge a deep cycle battery as soon as possible after each use to prevent sulfation. Therefore, the best time to water your batteries is always at the end of the charge cycle. You should consult a professional or visit the nearest ICON service center for a faulty charging system. The first move is plugging in the charger to see the charge status. Dealer reprogrammed the charger software and so far so good. If there was overflow on top of the battery, remember that the overflow is acidic. Ensure there are no leaks or acid build-up around the battery or in the battery compartment, as this will indicate a leak, which needs to be fixed without delay. ICON golf cart battery issues arise due to: Low charge Damage because of poor charging habits The battery is past its service life The battery terminals may be loose or corroded. #4. The short flash indicates that the golf cart battery is charged less than 80%. ICON golf cart issues are not necessarily a deal breaker, considering they are regular occurrences with other electric golf cart models. An example of data being processed may be a unique identifier stored in a cookie. Gas Club Car Governor Adjustment Everything You Need To Know, How To Remove Golf Cart Steering Wheel? The best thing to do is to park the golf cart on a flat surface while you change the tire. Check 10 Unique Icon Golf Cart Accessories, 10 Ariens Zero Turn Mower Problems and Solutions, 7 Most Common Can Am Defender Problems And Solutions. Solving problems wont take much time if you know them beforehand. With the key in the off position, plug your charge cord into the cart and wait till the charge indicator on the body turns green. #6. There can be several issues that may prevent the ICON golf carts from running. I am having battery/charger issues. When your golf cart doesn't charge, go through checking the batteries first to establish whether this is the problem. Posted: Oct 23, 2016. The first 10 to 20 complete charge/discharge cycles are critical to ensure they reach 100%. All batteries, regardless of their chemistry, self-discharge. Sometimes, the Icon golf cart becomes unusable due to overinflated or saggy tires. The solenoid is a crucial component of golf carts, comprising a steel plunger and a thin wire coil going around the plunger. Check on parts like the motor, the solenoid, and the braking system, as they are the source of most hiccups. The addition of accessories is welcomed and encouraged. The following procedures can be followed to fix the solenoid of a cart: This is the easiest way to make your cart active again. Any authorized ICON EV dealer can perform warranty work on your cart, however, your original dealer is responsible for warranty work after the sale. If you find your batteries do start to charge, you need to keep the discharge levels at the recommended levels to avoid this situation in the future. 25 mi Distance per Charge < 20 ft Breaking Range 19 mph Max Speed (DOT Available through Dealer) 6.7 Min. Following this thread to see if anyone has updates. Corrosion leads to sulfate buildup, which will hinder the current flow. Since a solenoid helps to start your cart, it becomes impossible to move your cart if the solenoid has any problem. Because, it is always risky to work with any electric devices. That charge indicator will always light up red once the charger kicks on. You need to know what kind of batteries your cart has, and if they need maintenance, make sure you check them regularly. Experience the convenience of a downtown driver without the expense of an electric car. This will save you from the hassle of calling a mechanic and spending money on the repairs. If the terminal wires are rusted, then put hot water on the rusted areas and rub with a cloth to remove the rust. Work performed outside of an authorized ICON dealer or ICON Service Factory Center shall void the Limited Warranty. 1. Or perhaps you want to purchase this electric cart. That is why you should always handle and maintain your vehicle according to the user manual. Additionally, the complications are minor and fixable. In order to keep your golf carts batteries fully charged and always available, manufacturers recommend charging your golf carts batteries while the cart is plugged in all the time. A 36V cart may have six 6V batteries, or three 12V batteries, while a 48V cart can have eight 6V batteries, four 12V batteries, or even six 8V batteries. All batteries that come in your new ICON will be covered for a period of two years. A golf cart charger should last as long as your golf cart, but sometimes, the electronics inside the charger can fail, which will stop your golf cart from working. Dont fill the battery above the plates as it needs space for the liquid to expand, so you need to be very careful not to get the acid on your skin or in your eyes, so protective gear is recommended.if(typeof ez_ad_units!='undefined'){ez_ad_units.push([[300,250],'betterplaygolf_com-large-mobile-banner-1','ezslot_8',121,'0','0'])};__ez_fad_position('div-gpt-ad-betterplaygolf_com-large-mobile-banner-1-0'); If they are, then top up the battery (usually with distilled water) and see if that works on the charger; if the charger still doesnt pick up the batteries, you may have damaged the cells and need a replacement. Get new tires if the ones you have are severely out of shape. And yes, it is completely free of cost to charge your battery, right?if(typeof ez_ad_units != 'undefined'){ez_ad_units.push([[336,280],'golfertroop_com-banner-1','ezslot_7',106,'0','0'])};__ez_fad_position('div-gpt-ad-golfertroop_com-banner-1-0'); Sometimes your cart starts running fine, but a few moments later it gets stuck. Lycamobile $23 Plan Prepaid Sim Card Include 3 Month Service $38.24 Get it as soon as Tuesday, May 31 FREE Shipping on orders over $25 shipped by Amazon lycamobile sim card unlimited data plan preloaded sim card 6 month swim luca mobile sim canada sim lycra mobile lycra swim Product Description ,Please do not dial 622 to activate the sim card . Whereas the Icon i20 is limited to just two people. Hopefully they will guide you with a proper solution. Park your car within the length of the supplied charging cable to an outlet. To resolve this issue, replace the cable, try to flatten it out, tighten the lift kit nuts, or have an expert complete these tasks if you lack the necessary tools. Any and all expenses incurred in transporting the vehicle to and from ICON or an authorized dealer will be the sole responsibility of the cart owner unless otherwise noted by the service provider. It is known that a solenoids duty is to transmit current to the motor of the cart. A new solenoid may cost around 15$-110$. Uncover the motor to access the reset button located near the power supply. Cant find the answer(s) youre looking for? In most cases, charging issues are mainly battery-related, and a quick check could save you some frustration, time, and money. There are only a few specific reasons for slouching or overinflated tires. The I40 has a high speed 10.5:1 rear. When this happens, there are no other choices except to replace them, and if you get that kind of performance from your batteries, you have done very well indeed. For complicated situations, let an experienced mechanic take charge. An excessive amount of flashing suggests a faulty connection between the battery and the charger or an issue with the battery pack. Thorough probing of the brake unit will lead to the root of the ICON golf cart brake problems. Driving with low-pressure tires is rough and may wear parts of the suspension system. Is the golf cart not charging? I love my Evolution. Link To 48V Club Car On-Board Computers (OBC): http://ow.ly/2fpv50u5CHnToday on GCGTV, we'll look at how to solve the issues that failed OBC technology in Cl. This is a vast improvement over lead-acid batteries, which can take over 8 hours to fully charge. Many people think that because golf carts run from 12V that the current is less than from a wall socket, which is true. You can remedy this by using a general charger to charge each battery separately to boost the charge and then hook it to the charger and see if it works. But make sure to check the terminal cables, voltage regulator, spark plugs etc before changing the batteries. Last but not the least, a problematic solenoid can ruin your journey with a Icon golf cart. Loose connections can cause an arc effect, which is not conducive for proper current flow between the batteries and the charger and the batteries and the carts onboard computer. The cause of a Club Car golf not charging is either a dead battery, a damaged power cable, or a faulty charger. Never add electrolyte to a battery that is not fully charged,just add distilled water and do not overfill. Those can be: To solve brake-related issues, you do not need a lot of money as the price of the cables does not exceed more than 220$. Finally, if all the above solutions dont work, then your tires are expired, and you need to replace them with a new tire.if(typeof ez_ad_units != 'undefined'){ez_ad_units.push([[250,250],'golfertroop_com-large-mobile-banner-1','ezslot_12',109,'0','0'])};__ez_fad_position('div-gpt-ad-golfertroop_com-large-mobile-banner-1-0'); To change the defective tires, you can buy new ones within 50$-200$. Most golf carts use lead-acid batteries, some are sealed batteries, and some are wet and need distilled water top-ups, and some golf cart owners have switched to lithium-ion, even though they are more expensive. Are ICON Golf Cart Problems A Deal Breaker? Still, some high amperages and voltages run through the electrical system, and if the wiring is poor, thin, or frayed, it adversely affects the charging and output. Dispose of your battery carefully as lead-acid batteries can be an environmental hazard. Do not let the rag or paper towel get wet enough to drip on other parts of the car. Unlike the traditional lead-acid golf cart batteries, which have an average of 500 charge cycles, a lithium-ion battery has the ability to reach a peak of 5,000 charge cycles. Icon Golf Cart is the perfect street-legal electric cart that is suitable for both, residential and commercial needs. I was at the center of caring for and maintaining this lawn and even proceeded to take an associates Degree in landscaping. So, in this article, we are going to talk about the common problems and solutions of Icon Golf Cart so that you have the basic guidelines to solve the problem. These variants are Icon Golf Cart i20, i40, i40L, and i40F. Even though you may think its a charging problem, it is not related. CHEAP POWER! The biggest benefit of lithium-ion batteries come in the form of their longer life. Even after taking all the necessary precautions, you might get other kinds of problems with your cart. A new solenoid of course will serve better than an old or damaged one. If you get that, then dont panic, please! If you still need help, please contact your local dealer, or our support team, and we will be in touch as soon as possible. Pour the solution over the terminals and let it work; you should see some bubbling, especially if there is residue, and then use an old toothbrush to scrub the terminals clean. It is a very easy fix and can be done in 3 steps. Even though they are more expensive than FLA, the lack of maintenance and better performance persuades many golf cart owners to use them. I talked to the dealer and they said that when you charge an ICON you need to switching the power switch (the one under the seat) to the "OFF" position and . I just got my icon about 4 weeks ago, same problem. Depending on the charger, you may need to either replace that cable or you may be able to pull the pin out using a pair of needle-nose pliers. There may well be no problem with the wiring or the batteries, but the charger itself may be having issues, and this is the reason your golf cart isnt charging. Because, an Icon golf cart is a machine and machines can have unwanted problems anytime . Get a brush for cleaning off corrosion and rags for wiping off leaking acid. If you are not confident to investigate why your golf cart isnt charging, refer back to your pro-shop or cart service technician to get your cart back in service as soon as possible. Your golf cart battery charger may need to be troubleshooted frequently. ICON golf cart battery issues arise due to: A faulty charging unit is another culprit behind the ICON utility vehicles starting problems. However, it will not cost more than 10$ -30$ to repair leaked or damaged tires. lbs). If you dont hear a click when you turn the key, then most likely you have a faulty solenoid, and this can be diagnosed and replaced by a technician, and the same would be valid for the direction switch. What is the Wire Size for Golf Cart Batteries? If your batteries are carrying a minimal load, and your charger will still not charge them, it may be because your golf cart's onboard computer is confused about how much charge they are currently carrying. Using the wrong fuse may result in damage and void the warranty. If you use the Cart to bear overweight regularly, then it can also burn out your Cart motor.if(typeof ez_ad_units != 'undefined'){ez_ad_units.push([[300,250],'golfertroop_com-large-mobile-banner-2','ezslot_13',110,'0','0'])};__ez_fad_position('div-gpt-ad-golfertroop_com-large-mobile-banner-2-0'); If the track on which you are using the Cart is rough and uneven, it will put extra pressure on the motor and might burn out. if(typeof ez_ad_units != 'undefined'){ez_ad_units.push([[336,280],'golfertroop_com-medrectangle-4','ezslot_4',104,'0','0'])};__ez_fad_position('div-gpt-ad-golfertroop_com-medrectangle-4-0');The battery problem might occur because of a variety of reasons. Choose Your Own. Just an FYI for you fellow ICON owners. The cart zips nicely up to 25mph (I've seen 26 and 27 but most of the time flat-out my cart only hits 25mph.) Schedule your yearly service with your ICON dealer for critical fluid changes, grease the front end and other serviceable fittings, electrical services, overall inspection, tire rotation, etc. Check the main cables to make sure there isn't any corrosion. Do not interrupt the charge cycle until the charge indicator is green. Never leave the batteries in a state of discharge for extended periods of time. To solve battery-related problems, the following procedures can be followed:if(typeof ez_ad_units != 'undefined'){ez_ad_units.push([[336,280],'golfertroop_com-box-4','ezslot_6',105,'0','0'])};__ez_fad_position('div-gpt-ad-golfertroop_com-box-4-0'); Firstly, check whether the battery is charged or not. Plug the vehicle back in and repeat the charge cycle. Consider replacing the carts battery if you have used it for a long time. At a 40% state of charge, electrolyte will freeze if the temperature reaches approximately 16F. The Icon I40 is an electric vehicle hence it eliminates some of the problems that plague gasoline golf carts such as noise, pollution and the increasing cost of refueling. That may tear up the tires. This will result in unbalanced batteries. The rate of self-discharge depends on the type of battery, the age of the battery, and the storage temperature the batteries are exposed to. Otherwise, it will not be able to run properly. Options. Tampering with the charger or charger algorithms. Lets delve into this! They should also be tightened in proper sequence. RoyPow (USA) Technology Co., Ltd. is a technology leader in lithium battery R&D and manufacturing. It's beautiful and gets me to where I want to go without any problems. For most people, watering lead acid batteries on a monthly basis is a hated task. Another potential problem masquerading as a charging issue is a faulty solenoid or direction switch. The link cables connect the negative of the first battery to the positive of the next one and so forth and then complete the circuit by connecting the negative or ground cable of the cart to the last negative battery terminal and the golf cart positive to the first batterys positive terminal. Remember always to replace the fuse with the same one youve taken out, as the fuse specifications are particular for that charger model. If you find that the golf cart isnt charging after a few minutes on the general charger, then you may have depleted them too much and will need new batteries. how to do a Harley Davidson golf cart engine swap? Older golf carts with lead-acid batteries will struggle to charge if the distilled water levels in the battery drop. So, when you can not increase the speed of your cart, that probably means you need to repair or change your solenoid. If you bring your capacity less than 50% just once you can prematurely damage your batteries. Prevent motor issues by working within the carts limits. If it is low, give it time to fill up before starting the cart. It won't push you back in your seats but its a decent time. For stuck or entangled cables, you pull them out carefully. Some general obstacles that you may face while operating your Icon golf carts are: As there are problems, of course, there will be some possible solutions to fix those problems. The switch should be in this position every time the cart is charged. Most Club Car golf carts, for instance, have a top speed of 19 mph. Our family in a golf cart community with many courses just a short walk away and have been golfing, modifying golf carts, and playing with golf simulators for most of our life. Here is where the use of the battery and discharge levels play a role in the battery health as lead-acid batteries should only be discharged to a maximum of 50% capacity; beyond that, they can rapidly lose performance and reduce their ability to charge. So, the cart becomes useless for a while. The charge indicator will go from red to yellow to green depending on the state of charge. Youll Be Surprised! 10 vs 12 Golf Cart Wheels: Which Size Is The Best? Club Car Accelerator Micro Switch Location | Heres All You Need To Know! ). Press the key to reset the motor and cover. Inspect the battery to see if it is still functional. The frame structure of the two carts are different and does not allow for parts to be interchangeable.
Icon Golf Cart Charging Issues,
Contact Marjorie Taylor Greene Phone,
Articles I